Tri-z Help

[twgranger]

Well im having a problem with my Z. It was funning fine entill the next day and now it won't rev out. It is making that rich spuddring sound. Here are the things i have checked. Cleaned carb and went up and down on jets, cleaned air filter, checked the reeds, did a compression check and a couple other things but i can't remember right now. What else would cause it to do this? It will rev out fine when im in neutral but not when im riding. I need some help, i realy don't wany to take it to the shop so im open for opinions.

[LonesomeTriZ]

That sounds like similar problem I had a while back. The engine was getting enough feul at an idle but noe when I would throttle down. It turned out my feul pump was not pumping strong enough. So I rebiult it. That before I found out the vacume line that powerd it had to be replaced. long story short, check your feul pump.

You never know, I might actually know somehting.

[twgranger]

That sounds like similar problem I had a while back. The engine was getting enough feul at an idle but noe when I would throttle down. It turned out my feul pump was not pumping strong enough. So I rebiult it. That before I found out the vacume line that powerd it had to be replaced. long story short, check your feul pump.

You never know, I might actually know somehting.

I rebuilt it last year, one of the liners were ripped. Would it die on me that quick? I have clear hoses and i can see the gas flow pretty good.

[200xman]

Did you try a fresh plug?

[twgranger]

Did you try a fresh plug?

I have gone through more than a box of plugs from doing tests on this thing.

[LonesomeTriZ]

I still think it is feul related. I went through it what you described. If not that, have you checked your compression. I have also had a intake come aprt on my pro Hauler and it did the same thing. Once I replaced that it ran great.

[Darius1502]

Try a gravity feed bottle and see if it still does it at high speed. I have seen tons of weird things happen with my fuel pump.

Its probably one of the most common ailments so give it a shot.

[twgranger]

I still think it is feul related. I went through it what you described. If not that, have you checked your compression. I have also had a intake come aprt on my pro Hauler and it did the same thing. Once I replaced that it ran great.

The compression was great when i checked it and it held pressure. I spayed starting fluid around the engine to see if their where any air leaks and found nothing. The head gasket seems to be fine too. 03 ORANGE SHEE seems to think it might be a electrical problem.

[LonesomeTriZ]

I'm out of ideas then.

[twgranger]

I'm out of ideas then.

Me too

[Darius1502]

Did you try the gravity feed?

I know its frustrating....remember my Z was having trouble last week or so. Once I ran it hard....every cleared out and it got back to normal.

You can never rule out that fuel pump.

[LonesomeTriZ]

Did you try the gravity feed?

I know its frustrating....remember my Z was having trouble last week or so. Once I ran it hard....every cleared out and it got back to normal.

You can never rule out that fuel pump.

Agreed......

[twgranger]

Did you try the gravity feed?

I know its frustrating....remember my Z was having trouble last week or so. Once I ran it hard....every cleared out and it got back to normal.

You can never rule out that fuel pump.

I will check the pump tomorrow to see if their is any dirt in it. I rebuilt it last year. I bought a new needle and seat but that did nothing.

[BLAZERONE22]

I have a harness with the CDI and coil I could send you to help troubleshoot the electrical.

[twgranger]

I have a harness with the CDI and coil I could send you to help troubleshoot the electrical.

Pm sent.